Commercial Drivers License (CDL) Pre-Trip Inspection: Engine Compartment

Pre-Trip Inspection – ENGINE COMPARTMENT (ENGINE OFF)

Leaks/Hoses

  • Look for puddles on the ground.
  • Look for dripping fluids on the underside of the engine and transmission.
  • Inspect hoses for condition and leaks.

Oil Level

  • Indicate where the dipstick is located.
  • Make sure the oil level is within safe operating range. The level must be above the refill mark.

Coolant Level

  • Inspect the reservoir sight glass, orIf the engine is not hot, remove the radiator cap and check for visible coolant level.

Power Steering Fluid

  • Indicate where the power steering fluid dipstick is located.
  • Check for adequate power steering fluid level. The level must be above the refill mark.

Engine Compartment Belts

Check the following belts for snugness (up to 3/4 inch play at center of belt), cracks, or frays:

  • Power steering belt.
  • Water pump belt.
  • Alternator belt.
  • Air compressor belt.

Note: If any of the components listed above are not belt driven, you must:

  • Make sure the component(s) are operating properly, are not damaged or leaking, and are mounted securely.

Leave a Reply

Your email address will not be published. Required fields are marked *

%d bloggers like this: